Kia Cee'd: Panoramaroof / Repair procedures

Kia Cee'd JD Service Manual / Body (Interior and Exterior) / Panoramaroof / Repair procedures

Adjustment

Inspect Glass Alignment

1.	Check for abnormal noise or bending during operation.

2.	With the sunroof fully closed, check for water leakage.

The roof panel (B) should be even with the movable glass (A) weatherstrip, to within the standard value "E" all the way around. If not, make the following adjustment.

Tightening torque :

Standard value "E" [mm(in.)]

(1) Front edge : 1.2 mm (0.0472 in.)

(2) Rear edge : 1.0 mm (0.0394 in.)

If the position is not as specified, lightly loosen the glass adjusting screws (A) to adjust the glass height and tighten it.

•	Do not damage the screws.

[Front]

[Rear]

Operating The Panoramaroof Emergency Handle

Use the panoramaroof emergency handle to close and open the panoramaroof manually for the following case only.

•	To close the panoramaroof before driving a vehicle in a rainy day or on the highway if the panoramaroof can not be closed due to failure of the panoramaroof motor or controller.

Operating method.

•	Remove the roof trim.

•	Push the emergency handle up into the hexagonal drive of the panoramaroof motor. You must push hard enough to disengage the motor clutch; otherwise the emergency handle will slip due to incomplete fit in the motor.

•	Carefully turn the emergency handle clockwise to close the panoramaroof.

•	After closing the sunroof, wiggle the handle back and forth as you remove the tool from the motor, to ensure the motor clutch reengages.

•	A 5mm hex socket may be used in place of the emergency handle, with a” Speeder” type handle.

•	Do not use power tools to operate the panoramaroof.

•	Damaged to the components may occur.

Components and components location

Components (1) 1. Roof side molding 2. Movable glass 3. Panoramaroof frame assembly 4. Wind deflector 5. Impact cross memeer upper assembly 6. ...

Movable Glass Repair procedures

Replacement 1. Open the movable glass fully. 2. Loosen the movable glass mounting screws (A). ...

Other information:

Kia Cee'd JD Owners Manual: Manual transaxle operation
■ Type A ■ Type B The manual transaxle has 6 forward gears. This shift pattern is imprinted on the shift knob. The transaxle is fully synchronized in all forward gears so shifting to either a higher or a lower gear is easily accomplished. Depress the clutch pedal down ...

Kia Cee'd JD Service Manual: Engine Control Module (ECM) Repair procedures
Removal When replacing the ECM, the vehicle equipped with the immobilizer must be performed procedure as below. [In the case of installing used ECM] 1) Perform "ECM Neutral mode" ...